Low enough. Far enough. Great food. Good hotel. North Texas Regional was the only logical destination for our break-in flight. Plus, most of the flight path is over open prairie and farmland with abundant places to put down safely if the new engine craps out.
About the only inhospitable terrain on the entire route is a short stretch of rough canyon country south of Amarillo.
Naturally, that’s where it happened…
Thump! The plane shudders. The prop protests with an odd whine. Probably just an air pocket. Turbulence from a thermal. Nothing more than a pothole in the sky.
A strong smell of engine exhaust fills the cockpit.
Lisa and I exchange somber glances. That tense spot between my shoulders, which had largely faded away, is suddenly back with a vengeance. I study the engine monitor. RPM good, and steady. Oil pressure and temp in range, and steady. The two back cylinders are running hotter than their sisters in the nose of the plane, but all are steady and well below redline.
Then I see it: The exhaust gas temperature on the number two cylinder is… dancing? The blue bar on the CGR-30P engine monitor is jumping up and down. First showing 1,423 degrees, then indicating 1,215 degrees, next 1,372 degrees. The other three blue EGT bars are steady. Number two continues to vacillate. What could cause such a thing? Would a stuck valve cause erratic gas temps? I cock my head to one side, listening for any odd rhythms from the engine. All sounds good.
Below my wing canyons, ragged rocks, juniper trees. I ease the yoke back and start a shallow climb. Our planned refueling stop, at Childress, is still 20 Maalox moments… I mean minutes… away.
It’s the closest airport.
But other than the dancing EGT all appears well. The dull roar of the engine is steady, unchanging. Power and pressures perfect. All other temps in range. Healthy. There’s nothing to indicate a problem. I ask Lisa to email our mechanic: Should we worry? It’s a pointless exercise. It’s Saturday. He won’t read our missive until Monday. By then, either we’ll be back home or we’ll be in a crumbled pile of metal at the bottom of a canyon.
We fly on, the number two EGT the metronome to the silent song my engine is playing. The tense spot between my shoulders grows and spreads.
At last the badlands pass behind our tails, I back off on the throttle and drop back down to 800 feet. It’s my new favorite cruising altitude, 300 feet higher than race flying and the required minimum altitude to overfly any building, vehicle, boat, person, outhouse or henhouse—and higher than most cell phone towers are tall—while still down close enough to the ground to reveal all the interesting things there are to see. It’s also maximizing our odds of properly seating the piston rings on our new cylinders.
Finally, I roll into the pattern at Childress. The name rang a bell when we planned the flight, but I couldn’t conjure up a mental image of the place. We’ve landed at so many airports these last two years that they’re all a jumble in my head. Now that I see it below, the taxiway new black asphalt standing out in stark contrast to the old faded grey runway, I remember it as the place Lisa momentarily lined up on the taxiway coming in for a landing last year on our way home from the Mark Hardin Memorial Air Race. Normally I would tease her by asking if I should land on the one on the left or the one on the right, but I’m still worried about our engine. In fact, we’ve flown in near silence since the EGT started its erratic dance.
We glide down over the cotton fields and gently kiss the runway. As I throttle back the EGT drops to zero. We taxi to the fuel pumps, shut down, and get out the tool kit. The air is chilly, but the engine metal hot as I open up the cowl and peer in. I honestly don’t know what I expect to see. There’s no splattered oil on the cylinder. The exhaust stack is intact. I stare at the new probe that measures the temperature of the exhaust. The band that holds it in place is oddly oval, but then I realize that I don’t know what it’s supposed to look like.
The probe on the forward cylinder is nearly out of sight, so I decide to pop open the cowl on the copilot side so I can see what the probe looks like on the other side. It also has the oddly-shaped band, but I notice that there’s a spring over the wires that’s in a different spot. I go back to my side of the plane and poke at the sensor.
It falls out.
Ah. Problem solved. A wonky sensor, that’s all. I push it back into place and reset the retaining spring. I have no great expectation that my fix will hold, but at least I know the readings are nothing to worry about.
I check the oil and find the level hasn’t budged, a new experience for me, as our “old” engine was as fond of oil as an alcoholic sailor is of rum. I stretch, rotate my arms to loosen the knot in my back, and look around. Then it occurs to me: I’m 250 miles out from our home base, and our only issue on engine #3 is a loose sensor.
After all these months grounded, after two failed engine rebuilds, we’re back. We’re truly back in the air and free to move about the country.